Yamaha 2009 Midnight Warrior Uživatelský manuál

5PX-28199-17XV17PCY(C)XV17PCMY(C)OWNER’S MANUALRead this manual carefully before operating this vehicle.LIT-11626-22-34

2-12SAFETY INFORMATION EAU10283Be a Responsible OwnerAs the vehicle’s owner, you are respon-sible for the safe and proper operationof your motorcycle.

SAFETY INFORMATION2-22due to excessive speed or under-cornering (insufficient lean anglefor the speed).• Always obey the speed limit andnever travel f

SAFETY INFORMATION2-32● Do not run engine in poorly venti-lated or partially enclosed areassuch as barns, garages, or car-ports.● Do not run engine ou

SAFETY INFORMATION2-42Aftermarket Parts, Accessories, andModificationsWhile you may find aftermarket prod-ucts similar in design and quality togenuine

DESCRIPTION3-13EAU10410Left view1. Engine oil drain bolt (crankcase) (page 7-10)2. Shift pedal (page 4-7)3. Fuel tank cap (page 4-8)4. Helmet holder (

DESCRIPTION3-23EAU10420Right view1. Rear brake fluid reservoir (page 7-24)2. Battery (page 7-32)3. Engine oil filler cap (page 7-10)4. Air filter elem

DESCRIPTION3-33EAU10430Controls and instruments1. Clutch lever (page 4-6)2. Left handlebar switches (page 4-5)3. Speedometer (page 4-3)4. Tachometer u

INSTRUMENT AND CONTROL FUNCTIONS4-14EAU10460Main switch/steering lock The main switch/steering lock controlsthe ignition and lighting systems, and isu

INSTRUMENT AND CONTROL FUNCTIONS4-24To unlock the steeringPush the key in, and then turn it to“OFF” while still pushing it.EAU11003Indicator and warni

INSTRUMENT AND CONTROL FUNCTIONS4-34then go off for 3.0 seconds. If this oc-curs, have a Yamaha dealer check thevehicle.EAU11482Engine trouble warning

EAU10042Read this manual carefully before operating this vehicle. This manual should stay with this vehicle if it is sold.U5PX17E0.book Page 1 Monda

INSTRUMENT AND CONTROL FUNCTIONS4-44● two tripmeters (which show thedistance traveled since they werelast set to zero)● a fuel reserve tripmeter (whic

INSTRUMENT AND CONTROL FUNCTIONS4-545. Push the “SELECT” button to setthe brightness level.6. Turn the key to “OFF”.TIPWhen adjusting the meter lighti

INSTRUMENT AND CONTROL FUNCTIONS4-64EAU12400Dimmer switch “ / ” Set this switch to “” for the highbeam and to “” for the low beam.EAU12430Turn signal

INSTRUMENT AND CONTROL FUNCTIONS4-74EAU12870Shift pedal The shift pedal is located on the leftside of the engine and is used in com-bination with the

INSTRUMENT AND CONTROL FUNCTIONS4-84EAU13074Fuel tank cap To open the fuel tank capOpen the fuel tank cap lock cover, in-sert the key into the lock, a

INSTRUMENT AND CONTROL FUNCTIONS4-943. Wipe up any spilled fuel immedi-ately. NOTICE: Immediately wipeoff spilled fuel with a clean, dry,soft cloth, s

INSTRUMENT AND CONTROL FUNCTIONS4-104EAU34042Rider seat To remove the rider seat1. Insert the key into the seat lock,and then turn it counterclockwise

INSTRUMENT AND CONTROL FUNCTIONS4-114To release the helmet from the hel-met holderRemove the rider seat, remove the hel-met from the helmet holder, an

INSTRUMENT AND CONTROL FUNCTIONS4-124EAU34063Adjusting the shock absorber assembly This shock absorber assembly isequipped with a spring preload adjus

INSTRUMENT AND CONTROL FUNCTIONS4-1343. Tighten the locknut to the specifiedtorque. NOTICE: Always tightenthe locknut against the adjust-ing nut, and

INTRODUCTIONEAU10081Congratulations on your purchase of the Yamaha XV17PCY(C)/XV17PCMY(C). This model is the result of Yamaha’s vastexperience in the

INSTRUMENT AND CONTROL FUNCTIONS4-144below and have a Yamaha dealer re-pair it if it does not function proper-ly.EAU44891Ignition circuit cut-off syst

INSTRUMENT AND CONTROL FUNCTIONS4-154With the engine turned off:1. Move the sidestand down.2. Make sure that the engine stop switch is turned on.3. Tu

FOR YOUR SAFETY – PRE-OPERATION CHECKS5-15EAU15595Inspect your vehicle each time you use it to make sure the vehicle is in safe operating condition. A

FOR YOUR SAFETY – PRE-OPERATION CHECKS5-25EAU15605Pre-operation check list ITEM CHECKS PAGEFuel• Check fuel level in fuel tank.• Refuel if necessary.•

FOR YOUR SAFETY – PRE-OPERATION CHECKS5-35Throttle grip• Make sure that operation is smooth.• Check cable free play.• If necessary, have Yamaha dealer

OPERATION AND IMPORTANT RIDING POINTS6-16EAU15951Read the Owner’s Manual carefully tobecome familiar with all controls. Ifthere is a control or functi

OPERATION AND IMPORTANT RIDING POINTS6-262. Shift the transmission into the neu-tral position. (See page 6-2.) Theneutral indicator light should comeo

OPERATION AND IMPORTANT RIDING POINTS6-364. At the recommended shift pointsshown in the following table, closethe throttle, and at the same time,quick

OPERATION AND IMPORTANT RIDING POINTS6-461600 km (1000 mi) and beyondThe vehicle can now be operated nor-mally.NOTICEECA10310● Keep the engine speed o

PERIODIC MAINTENANCE AND ADJUSTMENT7-17EAU17232Periodic inspection, adjustment, and lu-brication will keep your vehicle in thesafest and most efficien

IMPORTANT MANUAL INFORMATIONEAU10132Particularly important information is distinguished in this manual by the following notations:This is the safety a

PERIODIC MAINTENANCE AND ADJUSTMENT7-27EAU17361Owner’s tool kit The owner’s tool kit is located under therider seat. (See page 4-10.)The service infor

PERIODIC MAINTENANCE AND ADJUSTMENT7-37EAU17600Periodic maintenance chart for the emission control system * Since these items require special tools, d

PERIODIC MAINTENANCE AND ADJUSTMENT7-47EAU32185General maintenance and lubrication chart No. ITEM ROUTINEINITIAL ODOMETER READINGS600 mi (1000 km) or

PERIODIC MAINTENANCE AND ADJUSTMENT7-579 *Swingarm pivot bearings• Check bearing assemblies for looseness.• Moderately repack with lithium-soap-based

PERIODIC MAINTENANCE AND ADJUSTMENT7-6718 * Sidestand switch• Check operation and replace if necessary.√√√√√√19 * Front fork• Check operation and for

PERIODIC MAINTENANCE AND ADJUSTMENT7-77* Since these items require special tools, data and technical skills, have a Yamaha dealer perform the service.

PERIODIC MAINTENANCE AND ADJUSTMENT7-87• Replace the brake hoses every four years and if cracked or damaged.U5PX17E0.book Page 8 Monday, May 19, 200

PERIODIC MAINTENANCE AND ADJUSTMENT7-97EAU19642Checking the spark plugs The spark plugs are important enginecomponents, which should be checkedperiodi

PERIODIC MAINTENANCE AND ADJUSTMENT7-107EAU19681Canister (for California only) This model is equipped with a canisterto prevent the discharging of fue

PERIODIC MAINTENANCE AND ADJUSTMENT7-1175. If the engine oil is at or below theminimum level mark, add sufficientoil of the recommended type toraise i

IMPORTANT MANUAL INFORMATIONEAU10193XV17PCY(C)/XV17PCMY(C)OWNER’S MANUAL©2008 by Yamaha Motor Corporation, U.S.A.1st edition, May 2008All rights reser

PERIODIC MAINTENANCE AND ADJUSTMENT7-127TIPSkip steps 7–9 if the oil filter cartridge isnot being replaced.7. Remove the oil filter cartridge withan o

PERIODIC MAINTENANCE AND ADJUSTMENT7-137through the filler hole, insert thedipstick, and then tighten the oil fill-er cap.12. Start the engine, rev it

PERIODIC MAINTENANCE AND ADJUSTMENT7-147EAU20051Transfer case oil The transfer case must be checked foroil leakage before each ride. If anyleakage is

PERIODIC MAINTENANCE AND ADJUSTMENT7-157b. Remove the nuts.c. Disconnect fuel hose B fromthe joint as shown.d. Remove the hoses as shown,and then remo

PERIODIC MAINTENANCE AND ADJUSTMENT7-1676. Remove the air filter case cover byremoving the screws.7. Remove the air filter element byremoving the scre

PERIODIC MAINTENANCE AND ADJUSTMENT7-177hoses are properly connectedand routed, and are notpinched. WARNING! Beforeinstalling the fuel tank, makesure

PERIODIC MAINTENANCE AND ADJUSTMENT7-187EAU44732Checking the engine idling speed Check the engine idling speed and, ifnecessary, have it adjusted by a

PERIODIC MAINTENANCE AND ADJUSTMENT7-197EAU21751Tires To maximize the performance, durabil-ity, and safe operation of your motor-cycle, note the follo

PERIODIC MAINTENANCE AND ADJUSTMENT7-207WARNINGEWA10580● It is dangerous to ride with aworn-out tire. When a tire treadbegins to show crosswise lines,

PERIODIC MAINTENANCE AND ADJUSTMENT7-217“broken in”. Therefore, it is ad-visable before doing any high-speed riding to ride conserva-tively for approx

TABLE OF CONTENTSLOCATION OF IMPORTANT LABELS ...1-1SAFETY INFORMATION ...2-1DESCRIPTION ..

PERIODIC MAINTENANCE AND ADJUSTMENT7-227TIPIf the specified clutch lever free playcould be obtained as described above,tighten the locknut and skip th

PERIODIC MAINTENANCE AND ADJUSTMENT7-2373. Tighten the locknut.WARNINGEWA10630● After adjusting the brake leverfree play, check the free playand make

PERIODIC MAINTENANCE AND ADJUSTMENT7-247the point that a wear indicator almosttouches the brake disc, have a Yamahadealer replace the brake pads as a

PERIODIC MAINTENANCE AND ADJUSTMENT7-257Before riding, check that the brake fluidis above the minimum level mark andreplenish if necessary. A low brak

PERIODIC MAINTENANCE AND ADJUSTMENT7-267EAU23040Drive belt slack The drive belt slack should be checkedand adjusted at the intervals specifiedin the p

PERIODIC MAINTENANCE AND ADJUSTMENT7-2773. To tighten the drive belt, turn theadjusting bolt on each side of theswingarm in direction (a). To loos-en

PERIODIC MAINTENANCE AND ADJUSTMENT7-287EAU23111Checking and lubricating the throttle grip and cable The operation of the throttle grip shouldbe check

PERIODIC MAINTENANCE AND ADJUSTMENT7-297EAU23142Checking and lubricating the brake and clutch levers Brake leverClutch leverThe operation of the brake

PERIODIC MAINTENANCE AND ADJUSTMENT7-307EAUM1650Lubricating the swingarm piv-ots The swingarm pivots must be lubricat-ed at the intervals specified in

PERIODIC MAINTENANCE AND ADJUSTMENT7-317NOTICEECA10590If any damage is found or the frontfork does not operate smoothly,have a Yamaha dealer check or

TABLE OF CONTENTSReplacing a turn signal light bulb ...7-36Replacing a license plate light bulb ...

PERIODIC MAINTENANCE AND ADJUSTMENT7-327EAU33653Battery This model is equipped with a VRLA(Valve Regulated Lead Acid) battery.There is no need to chec

PERIODIC MAINTENANCE AND ADJUSTMENT7-3372. If the battery will be stored for morethan two months, check it at leastonce a month and fully charge it if

PERIODIC MAINTENANCE AND ADJUSTMENT7-3474. Turn the key to “ON” and turn onthe electrical circuit in question tocheck if the device operates.5. If the

PERIODIC MAINTENANCE AND ADJUSTMENT7-3572. Disconnect the headlight coupler,and then remove the bulb cover.3. Unhook the headlight bulb holder,and the

PERIODIC MAINTENANCE AND ADJUSTMENT7-367EAU24212Replacing a turn signal light bulb 1. Remove the turn signal lens by re-moving the screws.2. Remove th

PERIODIC MAINTENANCE AND ADJUSTMENT7-3774. Insert a new bulb into the socket.5. Install the license plate light lensby installing the washers and then

PERIODIC MAINTENANCE AND ADJUSTMENT7-387EAU25851Troubleshooting Although Yamaha motorcycles receivea thorough inspection before shipmentfrom the facto

PERIODIC MAINTENANCE AND ADJUSTMENT7-397EAU42601Troubleshooting chart Check the fuel level inthe fuel tank.1. FuelThere is enough fuel.There is no fue

MOTORCYCLE CARE AND STORAGE8-18EAU37833Matte color caution NOTICEECA15192Some models are equipped withmatte colored finished parts. Besure to consult

MOTORCYCLE CARE AND STORAGE8-28contact with strong or abrasivecleaning products, solvent orthinner, fuel (gasoline), rust re-movers or inhibitors, bra

LOCATION OF IMPORTANT LABELS1-11EAU10383Read and understand all of the labels on your vehicle. They contain important information for safe and proper

MOTORCYCLE CARE AND STORAGE8-385. Touch up minor paint damagecaused by stones, etc.6. Wax all painted and chrome-plat-ed surfaces. Avoid combinationcl

MOTORCYCLE CARE AND STORAGE8-483. Perform the following steps to pro-tect the cylinders, piston rings, etc.from corrosion.a. Remove the spark plug cap

SPECIFICATIONS9-19Dimensions:Overall length:2385 mm (93.9 in)Overall width:935 mm (36.8 in)Overall height:1120 mm (44.1 in)Seat height:730 mm (28.7 in

SPECIFICATIONS9-29Chassis:Frame type:Double cradleCaster angle:29.25 °Trail:130.0 mm (5.12 in)Front tire:Type:TubelessSize:120/70 ZR18M/C (59W)Manufac

SPECIFICATIONS9-39Bulb voltage, wattage × quantity:Headlight:12 V, 60 W/55.0 W × 1Tail/brake light:LEDFront turn signal/position light:12 V, 23 W/8.0

CONSUMER INFORMATION10-110EAU26351Identification numbers Record the key identification number,vehicle identification number and mod-el label informati

CONSUMER INFORMATION10-210EAU26470Model label The model label is affixed to the frameunder the rider seat. (See page 4-10.)Record the information on t

CONSUMER INFORMATION10-310EAU26551Reporting safety defects If you believe that your vehicle has a defect which could cause a crash or could cause inju

CONSUMER INFORMATION10-410EAU26560Motorcycle noise regulation TAMPERING WITH NOISE CONTROL SYSTEM PROHIBITED:Federal law prohibits the following acts

CONSUMER INFORMATION10-510EAU26632Maintenance record Copies of work orders and/or receipts for parts purchased and installed on your vehicle will be r

LOCATION OF IMPORTANT LABELS1-2124California only135California onlyU5PX17E0.book Page 2 Monday, May 19, 2008 2:44 PM

CONSUMER INFORMATION10-61036000 mi(55000 km) or54 months40000 mi(61000 km) or60 monthsMaintenanceintervalDate ofserviceMileageServicing dealername and

CONSUMER INFORMATION10-710EAU26663YAMAHA MOTOR CORPORATION, U.S.A. STREET AND ENDURO MOTORCYCLE LIMITED WARRANTY a)b)c)d)e)f)1.2.Yamaha Motor Corporat

CONSUMER INFORMATION10-810WARRANTY QUESTIONS AND ANSWERSWhat costs are my responsibility during the warranty period?The customer’s responsibility incl

CONSUMER INFORMATION10-910EAU26750YAMAHA EXTENDED SERVICE (Y.E.S.) Keep your Yamaha protected even after your warranty expires with genuine Yamaha Ext

CONSUMER INFORMATION10-1010We urge you to act now. You’ll get the excellent benefits of TRIP coverage right away, and you’ll rest easy knowing you’ll

INDEXAAir filter elements, replacing ... 7-14BBattery ... 7-32Brake and clutch levers, ch

INDEXVehicle identification number... 10-1WWarranty, extended... 10-9Warranty, limited...

U5PX17E0.book Page 3 Monday, May 19, 2008 2:44 PM

PRINTED IN JAPAN2008.05-0.5×1 CR(E)PRINTED ON RECYCLED PAPER YAMAHA MOTOR CO., LTD.